10-02-2017, 10:04 AM
Sorry for the long delay on this post. I needed 2 ea that had broke when torqing. I did order them from suzukiparts website. The parts actually came from Toms Truck Center in Garden Grove, CA. I ordered a few extra for future just in case. The rebuild went good. It took a lot of time but turned out great. Without this website I never could have completed this rebuild. Thank you Fixkick and all that post here. So to sum it up. The engine had been rebuilt by Jasper sometime in the past. I did have the crankshaft ground. It had some grooving on the journals. The cylinders were already bored .75 mm over. The pistons and cylinders all looked good and measured with in tolerance so I installed new piston rings and honed the cylinders. Replaced oil pump, water pump, timing belt kit, EGR valve, and new exhaust to include Cat and oxygen sensors. I currently have about 2,000 miles on the rebuild and man does it have power compared to before the teardown. Again thank you fixkick for having this forum and the website with all the information.